2004 Touring DTC (diagnostic trouble code) : V-Twin Forum: Harley Davidson Forums
» Sponsors

» Insurance
Go Back   V-Twin Forum : Harley-Davidson Motorcycle Forums > Technical Discussion Forums > Twin-Cam 88" Engine Technical Discussion
New User? Register Forgot Password

Reply
 
LinkBack Thread Tools Display Modes
Old 08-25-2004, 09:33 PM   #1 (permalink)
Seasoned Rider
 
Join Date: Apr 2004
Location: Newark, CA
Posts: 46
gsparesa wants to know Dino or Syn?
2004 Touring DTC (diagnostic trouble code)

The IM (instrument module) is capable of displaying DTC's (diagnostic trouble codes).
Speedometer Self Diagnostics: The speedometer is capable of displaying and clearing speedometer, tachometer, TSM/TSSM and ICM/ECM Diagnostic Trouble Codes (DTC).

1- Turn Ignition switch to OFF & Run/Stop switch is to Run.

2- Push odometer reset button in & hold.

3- Turn ignition switch to Ignition and release odometer reset button. Background lighting sould illuminate, speedometer needle should sweep its full range and indicator lamps (battery, security, low fuel, check engine and cruise) should illuminate. The word “diag” should then appear.

4 - Push the odometer reset button once and you will see the selection menu "PSSPt" with the first P flashing.

5 - Each letter represents an area of the diagnostics module. The module that is flashing is the one you are going to check. To move from one letter (module) to the next, you push the odometer reset button one time. (from P to S to SP to t and back to P, etc.)
P = ECM/ICM (Electronic Control Module [EFI] / Ignition Control Module [Carbureted])
S = TSM/TSSM (Turn Signal/ Turn Signal Security Module)
SP = speedometer
T = tachometer

6 - To get the DTC within an area of diagnostics, push and hold the odometer reset button in for 5 seconds and release. If there are any DTC’s the code will be displayed or the word “none” will appear if there are no DTC’s. Push the odometer reset button again to view additional codes if they exist.

7 - Record the codes.

8 - If DTC’s are not to be cleared, Press and release the odometer reset button. Part number of module will be displayed.
NOTE: To determine if a code is current or historic, clear the displayed code by pushing in and holding the odometer reset button ( longer than 5 seconds) until 'clear' comes up. Release the odometer reset button. Turn OFF the ignition switch. Run your bike and shut it down then recheck the DTC’s again by repeating steps 1 to 9. If the code is current it will reappear.

9 – Press and release the odometer reset button to continue to the next module.

10 – Turn Ignition switch to OFF.

--------------------------

DTC FAULT CONDITION MODULE

B0563 Battery Voltage High TSM/TSSM
B1004 Fuel Level Sending Unit Low Instruments
B1005 Fuel Level Sending Unit High/Open Instruments
B1006 Accessory Line Overvoltage Instruments
B1007 Ignition Line Overvoltage Instruments
B1008 Reset Switch Closed Instruments
B1131 Alarm Output Low TSM/TSSM
B1132 Alarm Output High TSM/TSSM
B1134 Starter Output High TSM/TSSM
B1135 Accelerometer Fault TSM/TSSM
B1151 Sidecar BAS Low TSM/TSSM
B1152 Sidecar BAS High TSM/TSSM
B1153 Sidecar BAS Out of Range TSM/TSSM
P0106 MAP Sensor Rate of Range Error Carb
P0107 Map Sensor Failed Open/Low Carb
P0107 Map Sensor Open/Low EFI
P0108 Map Sensor Failed High Carb
P0108 Map Sensor High EFI
P0112 IAT Sensor Voltage Low EFI
P0113 IAT Sensor Voltage Open/High EFI
P0117 ET Sensor Voltage Low EFI
P0118 ET Sensor Voltage Open/High EFI
P0122 TP Sensor Open/Low EFI
P0123 TP Sensor High EFI
P0261 Front Injector Open/Low EFI
P0262 Front Injector High EFI
P0263 Rear Injector Open/Low EFI
P0264 Rear Injector High EFI
P0373 CKP Sensor Intermittent Carb
P0373 CKP Sensor Intermittent EFI
P0374 CKP Sensor Not Detected Carb
P0374 CKP Sensor Synch Error EFI
P0501 VSS Low Carb
P0501 VSS Low EFI
P0502 VSS High/Open Carb
P0502 VSS High/Open EFI
P0505 Loss of Idle Sped Control EFI
P0562 Battery Voltage Low Carb
P0562 Battery Voltage Low EFI
P0563 Battery Voltage High Carb
P0563 Battery Voltage High EFI
P0602 Calibration Memory Error Carb
P0603 EEPROM Failure Carb
P0603 ECM EEPROM Error EFI
P0604 RAM Failure Carb
P0605 Program Memory Error Carb
P0605 ECM Flash Error EFI
P0607 Converter Error Carb
P1001 System Relay Coil Open/Low EFI
P1002 System relay Coil High/Shorted EFI
P1003 System relay Contacts Open EFI
P1004 System Relay Contacts Closed EFI
P1009 Incorrect Password Carb
P1009 Incorrect Password EFI
P1010 Missing Password Carb
P1010 Missing Password EFI
P1351 Front Ignition Open/Low Carb
P1351 Front Ignition Open/Low EFI
P1352 Front Ignition Coil High/Shorted Carb
P1352 Front Ignition Coil High/Shorted EFI
P1353 Front Cylinder No Combustion EFI
P1354 Rear Ignition Coil Open/Low Carb
P1354 Rear Ignition Coil Open/Low EFI
P1355 Rear Ignition Coil High/Shorted Carb
P1355 Rear Ignition Coil High/Shorted EFI
P1356 Rear Cylinder No Combustion EFI
P1357 Intermittent Secondary Front EFI
P1358 Intermittent Secondary Rear EFI
U1016 Loss of ICM/ECM Serial Data Instruments
U1016 Loss of ECM Serial Data, Vehicle Speed, Vehicle Inhibit Motion or Powertrain Security Status TSM/TSSM
U1064 Loss of TSM/TSSM Serial Data Carb
U1064 Loss of TSM/TSSM Serial Data EFI
U1064 Loss of TSM/TSSM Serial Data Instruments
U1097 Loss of Speedometer Serial data Carb
U1097 Loss of Speedometer Serial data EFI
U1097 Loss of Speedometer Serial data TSM/TSSM
U1255 Missing Message at Speedometer EFI
U1255 Serial Data Error/Missing Message EFI
U1255 Serial Data Error/Missing Message Instruments
U1255 Serial Data Error/Missing Message TSM/TSSM
U1300 Serial Data Low Carb
U1300 Serial Data Low EFI
U1300 Serial Data Low Instruments
U1300 Serial Data Low TSM/TSSM
U1301 Serial Data Open/High Carb
U1301 Serial Data Open/High EFI
U1301 Serial Data Open/High Instruments
U1301 Serial Data Open/High TSM/TSSM

-----------------------

AFR – Air Fuel Ratio

ATS – Air Temperature Sensor

BAS – Bank Angle Sensor

CCM – Cruise Control Module

CKP – Crank Position Sensor. The CKP generates an “AC signal” which is sent to the ECM where it is used to reference engine position (TDC) and speed. Home position established by taking readings off the 22 teeth on the alternator rotor.

DTC – Diagnostic Trouble Codes

ECM – Electronic Control Module. (The Computer) Computes the spark advance for proper ignition timing and fuel control based on sensor inputs (from CKP, MAP & TP sensors) and controls the low-voltage circuits for the ignition coils and injectors. The dwell time for the ignition coil is also calculated in the microprocessor and is dependent upon battery voltage. The programmed dwell feature gives adequate spark at all speeds.

ECT – Engine Coolant Temperature. Sensor also controls the cooling fan relay that provides 12 Vdc to the fans.

EFI – Electronic Fuel Injection

EFP – Electronic Fuel Pump

ET – Engine Temperature sensor

FI – Fuel Injectors

FPR – Fuel Pressure regulator

IAC – Idle Air Control actuator

IAT – Intake Air Temperature sensor

ISS – Ion Sensing System…detonation detection

MAP – manifold Absolute Pressure sensor. The MAP sensor monitors the intake manifold pressure (vacuum) and sends the information to the ECM. The EMC then adjusts the spark and fuel-timing advance curves for optimum performance.

TP – Throttle Position Sensor

TSM/TSSM (Turn Signal/ Turn Signal Security Module)

VE – Volume Efficiency

VSS – Vehicle Speed Sensor. Used as an input for idle speed control
__________________
Ride to Eat - - Eat to Ride
gsparesa is offline   Reply With Quote
Sponsored Links
Advertisement
 
Old 08-26-2004, 05:40 AM   #2 (permalink)
IronButt
 
Join Date: Mar 2004
Location: Houston
Posts: 130
rell3081 wants to know Dino or Syn?
Thankyou very much for putting this up for the rest of us. It has helped me alot.
rell3081 is offline   Reply With Quote
Old 08-26-2004, 09:52 AM   #3 (permalink)
Highly Seasoned Rider!
 
newultraclassic's Avatar
 
Join Date: Aug 2004
Location: Sacramento County, California
Posts: 4,884
newultraclassic wants to know Dino or Syn?
Yes, thanks a lot. I have an '04 tourer....sooner or later, I'm sure this will come in handy.
newultraclassic is offline   Reply With Quote
Old 08-26-2004, 10:47 AM   #4 (permalink)
IronButt
 
Join Date: Mar 2004
Location: NC Tarheel
Posts: 278
Bluescb wants to know Dino or Syn?
Great post gs-- Thanks
__________________
When I 'act my age'---shoot me
Bluescb is offline   Reply With Quote
Old 08-26-2004, 12:37 PM   #5 (permalink)
FNG :)
 
Join Date: Nov 2002
Location: Seattle
Posts: 28
Minglewood wants to know Dino or Syn?
Stickey, if I ever saw one. Thanks.
Minglewood is offline   Reply With Quote
Old 08-27-2004, 07:28 PM   #6 (permalink)
Premium Member
 
Join Date: Jul 2004
Location: In the country, Wisconsin
Posts: 4,701
hdmarsh77 wants to know Dino or Syn?
This is the most useful post I've seen for me. Is there a way to print this?
hdmarsh77 is offline   Reply With Quote
Old 08-28-2004, 12:58 AM   #7 (permalink)
IronButt
 
Ed Y's Avatar
 
Join Date: Aug 2002
Location: Kokomo, MS
Posts: 6,324
Ed Y wants to know Dino or Syn?
Just do a copy and paste to Notepad or Word, etc.
__________________
Ed Y
2002 FLTRI
I yam what I yam.
Ed Y is offline   Reply With Quote
Old 08-28-2004, 05:26 AM   #8 (permalink)
IronButt
 
Join Date: Mar 2004
Location: Houston
Posts: 130
rell3081 wants to know Dino or Syn?
My light has come on a couple of times but all i get in the P section is no rps. Everything else is no code. What is no rps?
rell3081 is offline   Reply With Quote
Old 08-28-2004, 04:42 PM   #9 (permalink)
Premium Member
 
Join Date: Jul 2004
Location: In the country, Wisconsin
Posts: 4,701
hdmarsh77 wants to know Dino or Syn?
Quote:
Originally Posted by Ed Y
Just do a copy and paste to Notepad or Word, etc.

Will do. Thanks Ed.
hdmarsh77 is offline   Reply With Quote
Old 09-08-2004, 08:49 PM   #10 (permalink)
rtb
03 Heritage
 
rtb's Avatar
 
Join Date: Sep 2004
Location: Charlotte, NC
Posts: 491
rtb wants to know Dino or Syn?
Thumbs up Thanks for the info.

I hope to never need it, but I'm grateful if I do.
rtb is online now   Reply With Quote
Old 09-17-2004, 08:06 PM   #11 (permalink)
Seasoned Rider
 
02 ultra rider's Avatar
 
Join Date: Mar 2004
Location: Portland, Or.
Posts: 91
02 ultra rider wants to know Dino or Syn?
Thanks for posting this info. My light stayed on for 5 sec. today when I got off work. I just had the 95 inch kit put on, so I'm going to check it out and see if it's related. Thanks again.
__________________
Now proud owner of an '08 Ultra
02 ultra rider is offline   Reply With Quote
Old 09-21-2004, 01:26 PM   #12 (permalink)
IronButt
 
Join Date: May 2002
Location: UK for now........
Posts: 4,091
harleyhog wants to know Dino or Syn?
Where have I seen this before LOL.
http://www.harleyhog.co.uk/0405troublecodes.htm
__________________
Animations powered by elsewhere...

Click da Hog...Go on, ya know ya wanna.

harleyhog is offline   Reply With Quote
Old 09-30-2004, 06:32 PM   #13 (permalink)
Seasoned Rider
 
Join Date: Apr 2004
Location: Newark, CA
Posts: 46
gsparesa wants to know Dino or Syn?
Quote:
Originally Posted by harleyhog
Where have I seen this before LOL.
http://www.harleyhog.co.uk/0405troublecodes.htm
Damn...What a cut and paste job. I posted it on two news groups only, this one and Harley Davidson Forums. I guess I should be flattered.
__________________
Ride to Eat - - Eat to Ride
gsparesa is offline   Reply With Quote
Old 10-01-2004, 12:53 AM   #14 (permalink)
IronButt
 
Join Date: May 2002
Location: UK for now........
Posts: 4,091
harleyhog wants to know Dino or Syn?
Considering I got this from HIPPO in HTT months ago I think HIPPO should be the one being flattered.
__________________
Animations powered by elsewhere...

Click da Hog...Go on, ya know ya wanna.

harleyhog is offline   Reply With Quote
Old 10-01-2004, 08:16 AM   #15 (permalink)
Seasoned Rider
 
Join Date: Apr 2004
Location: Newark, CA
Posts: 46
gsparesa wants to know Dino or Syn?
Quote:
Originally Posted by harleyhog
Considering I got this from HIPPO in HTT months ago I think HIPPO should be the one being flattered.
Who the f*ck is HIPPO in HTT? If they did then they got it off my freakin' computer or the WEB sites I mentioned above. It took me quit a while to type that crap in the computer using microsoft word. You freakin' theives. (O)'s
__________________
Ride to Eat - - Eat to Ride
gsparesa is offline   Reply With Quote
Sponsored Links
Advertisement
 
Reply

Thread Tools
Display Modes

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off
Trackbacks are Off
Pingbacks are Off
Refbacks are On


Powered by vBadvanced CMPS v3.2.2

All times are GMT -5. The time now is 11:45 PM.


Powered by vBulletin® Copyright ©2000 - 2014, Jelsoft Enterprises Ltd.
Content Relevant URLs by vBSEO 3.6.0
(C)2001-2012 V-twinForum.com All Rights Reserved (C)2001- V-twinForum.com All Rights Reserved
Motorcycle News, Videos and Reviews
Honda Grom Forum Harley Davidson Forum Honda 600RR Kawasaki Forum Yamaha R6 Forum Yamaha FZ-09 Forum
1199 Panigale Forum Roadglide Forum Honda CBR1000 Forum Vulcan Forum Yamaha R1 Forum Yamaha R3 Forum
Ducati Monster Forum Harley Forums Honda CBR250R Forum ZX10R Forum Star Raider Forum Yamaha Viking Forum
Suzuki GSXR Forum V-Rod Forums Honda Shadow Forum Kawasaki Motorcycle Forum Star Warrior Forum KTM Duke 390 Forum
SV650 Forum BMW S1000RR Forum Honda Fury Forum Kawasaki Versys Forum Drag Racing Forum Ducati 899 Panigale Forum
Suzuki V-Strom BMW K1600 Triumph Forum Victory Forums Sportbikes BMW NineT Forum
Volusia Forum BMW F800 Forum Triumph 675 Forum MV Agusta Forum HD Street Forum Suzuki GW250 Forum
Yamaha Motorcycles Victory Gunner Forum Honda Vultus Forum HD LiveWire Forum